設為首頁
加入收藏
聯系我們
1、確定儀器要安裝的房間，ICP光譜儀是大型精密儀器，尤其是進口儀器，對使用環境的條件要求比較高。
1, to determine the equipment to be installed in the room, ICP spectrometer is a large precision instruments, especially imported equipment, the use of the conditions of the environment is relatively high.
2、要有良好的用電環境，ICP在點火的瞬間，功率還是很大的，所以電源要不低于10千瓦，實驗室要單獨供電，特別是企業，不要和其它大功率的生產設備共用電源，因?yàn)槠渌蠊β试O(shè)備啟動時會對儀器測試造成比較大的影響，甚至損壞儀器。電壓要相對穩定，頻率也要穩定，可以用示波器去監測，要有良好的正弦波形，不能有脈沖或方波。最好要有穩壓電源，向廠家咨訊購買何種型號的穩壓電源。不是每一種穩壓電源都是可以使用的。我也曾遇到過電的問題，企業有可控硅生產線，結果整個電網頻率不穩，儀器怎么調也不穩，后來單獨拉了一條線，一切搞定。
2, have good electrical environment, ICP in the ignition moment, power is still very large, so the power of either less than 10 kilowatts, the laboratory should separate power supply, especially the enterprise, and not other high-power production equipment shared power supply, because other high-power equipment startup will have large effects on the test instrument and even damage the instrument. Voltage to be relatively stable, the frequency should be stable, you can use oscilloscope to monitor, to have a good sine wave, there is no pulse or square wave. It is best to have a regulated power supply to the manufacturers to buy what kind of regulated power supply. Not every kind of regulated power supply can be used. I have also encountered the problem of electricity, the company has a SCR production line, the results of the entire power grid frequency instability, the instrument is not stable how to tune, and then pulled a separate line, all get.
3、ICP光譜儀在使用中要有良好的通風，所以至少要在實驗室留下安裝通風的位置。也不要在沒有廠家安裝圖紙的情況下安裝好通風，到時候儀器來了有可能位置高度均不合適，哪樣就得重新安裝通風。如果想提前安裝，可以詢問廠家，一般廠家都會提供一個詳細的安裝圖紙，可以按圖紙安裝。
3, ICP spectrometer in use to have good ventilation, so at least in the laboratory to leave the installation of ventilation position. Don't install good ventilation in the absence of manufacturers installation drawings under the condition that the instrument may have height are not suitable, which will have to re install ventilation. If you want to install in advance, you can ask the manufacturers, general manufacturers will provide a detailed installation drawings, drawings can be installed.
希望大家在使用ICP單道掃描光譜儀的時候要做好以上這些。
Hope that we use the ICP single channel scanning spectrometer to do these.
